ComfortCostGuide

Metro cost guide

Grand Rapids, Michigan: HVAC Replacement Cost Calculator

Replacing HVAC equipment in Grand Rapids typically runs $3,500 to $7,000 installed for a gas furnace, $4,000 to $7,500 for central air conditioning, and $7,500 to $13,000 when you replace both at once. Heat pumps fall between $6,000 and $12,000, while ductless mini-splits range from $3,500 to $10,000 depending on how many zones you need. These are installed prices that include equipment and labor from local contractors.

Worked example

A 1,800-square-foot two-story home on the southeast side of Grand Rapids with a 22-year-old gas furnace and a matching AC condenser that has started leaking refrigerant. Because both units are near end of life and share the same ductwork and coil, the homeowner replaces them as a matched system rather than piecemeal. A mid-efficiency furnace paired with a standard-efficiency AC on existing ducts would land near the middle of the $7,500 to $13,000 range, around $10,000 installed. Adding a high-efficiency variable-speed furnace, a new line set, or duct repairs pushes the job toward the $13,000 top end.

Frequently asked questions

How much does it cost to replace a furnace and air conditioner together in Grand Rapids?

A combined furnace and AC replacement in Grand Rapids runs $7,500 to $13,000 installed. Bundling the two is usually cheaper than replacing them a few years apart because the crew does one trip, one set of electrical and refrigerant connections, and one coil match. Simple swaps on existing ductwork sit at the low end; high-efficiency equipment and duct or venting changes push toward the top.

Does a heat pump make sense in Grand Rapids winters?

Grand Rapids sits in climate zone 5, so winters are cold enough that heat pump sizing and backup heat matter. Installed heat pump costs here run $6,000 to $12,000, which overlaps the $7,500 to $13,000 range for a conventional furnace-and-AC system. Ask contractors to quote both, since the right choice depends on your home's insulation, ductwork, and whether you already have a gas line.

Why do HVAC labor costs vary so much on Grand Rapids quotes?

HVAC technicians in the Grand Rapids area earn about $31.01 per hour, which is right at the national average, so labor here is neither a bargain nor a premium. The bigger swing comes from job complexity: a straight furnace swap in an open basement takes far fewer hours than a crawlspace install, a new flue liner, or duct modifications. Ask each bid to break out labor hours so you can compare apples to apples.

What if my Grand Rapids home has no ductwork?

Ductless mini-splits run $3,500 to $10,000 installed in Grand Rapids, with the low end covering a single-zone system for one room or addition and the high end covering a multi-zone setup for several areas. They are a common fit for older Grand Rapids homes, finished attics, and additions where adding ducts would be invasive. Getting quotes for both a mini-split and a ducted system is worth it if any usable duct runs already exist.

Related cost guides